Page 1 of 1
Cracked RE
Posted: Sat Jun 04, 2005 5:39 am
by High Society
Last night I found a crack on one of my 8's, it extends from the tip of the surround till the edge of the dust cap. It's really hard to see it since I put the crack at level with each other, but I was wondering how big of a problem this is, and how can I fix it?
Posted: Sat Jun 04, 2005 6:04 am
by Ryan from Ohio
Well I got the fix for you. Same thing I did to these 10" ARCs.
Goto WAL Mart and get some fiberglass cloth and find some quality CA/Super Glue- not the cheap crap!
First put masking tape on the inside of the cone (where the logo is) so the glue doesnt seep thru the crack.
Cut a small piece of cloth that extends about 1-2" or so wide and to the needed length.
Lay cloth on back side of cone. Grab a few nice long tooth picks. Start from the lower center- drip a drop of glue- it will soak and sread. Blow on it a bit to aid in this. Give it a 30-i minute between drops while blowing on it or use a fan. DO this slowly until the whole piece of cloth is covered while using the toohpicks to press and hold the cloth down.
You will see when the cloth is covered...
Posted: Sat Jun 04, 2005 6:19 am
by High Society
It will hold up even if the front side isn't fixed like that then? How come any kind of super glue wont work?? If I didn’t find this crack and I installed it and started playing it, would it have gotten worse?
Posted: Sat Jun 04, 2005 9:30 am
by Ryan from Ohio
Use good glue=better results, better adhesion and more strength.
CA Glue from Hobby Stores is the BEST to use- DONT GET GEL!
Why just the back?
Well first is obvious- looks. The patch would make the sub look like crap.
The glue should have enough adhesion to hold the cloth tight to the cone and make the cloth strong.
Its the only way to fix this
Posted: Sat Jun 04, 2005 1:23 pm
by GlassWolf
those REs are fairly new aren't they?
send it back to RE and have them repair it under warranty before you go messing with a home repair.
Posted: Sat Jun 04, 2005 9:21 pm
by High Society
Well the one that's cracked wasn’t bought from RE. I got it off e-bay, from that audio shop that was going out off business. It is brand new tho, still has the masking tape over the vent hole, so I don't think it's under warranty since it was won on ebay??
Posted: Sun Jun 05, 2005 5:40 am
by Ryan from Ohio
I doubt the crack was from inferior material...
But I would give them a call and see. Maybe tell them it one you purchased? Dunno...